REACH-IN CO2 INCUBATOR OPERATIONS MANUAL FOR MODELS 6024, 6026, 6044, 6046 PO Box 715 Marietta, OH 45750 800-648-3042 740-373-6
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 10 of 56 Left Side Access Port Power Switch Control Panel Adjustable Sliding
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 11 of 56 SECTION 2 – EQUIPMENT OVERVIEW – CONTINUED INCUBATOR CONTROL PANEL
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 12 of 56 SECTION 3 -- INSTALLATION Unpacking Your new unit has been thorough
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 13 of 56 Installing the Port Stoppers The unit has an access port built into
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 14 of 56 Connecting the Drain The incubators control humidity by in
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 15 of 56 Use only distilled or deionized water with a resistivity between 50K
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 16 of 56 Connect each incubator to a grounded circuit. Failure to do so could
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 17 of 56 SECTION 4 – OPTIONAL ACCESSORY INSTALLATION Connecting Alarm Contact
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 18 of 56 Installing Carboy water system (BOTL301) Incubators can be purchas
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 19 of 56 Installing Cell Roller Ramp & Support Kit (CELR301) For applicat
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 2 of 56 Dear Valued Customer: Thank you for purchasing CARON Products &
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 20 of 56 Connecting Communications or Analog Outputs (DLUX303) With the pur
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 21 of 56 to 247 controllers (Modbus) or 16 controllers (Standard Bus). Chamb
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 22 of 56 Installing a Drain Water Pump (PUMP301) In applications where a floo
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 23 of 56 SECTION 5 –OPERATION With the incubator properly installed and
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 24 of 56 Changing the Humidity Set-point If an alternative humidity set-poi
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 25 of 56 Changing the CO2 Set-point If an alternative CO2 set-point is requir
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 26 of 56 Failure to remove the sensor will result in damage to the sensor and
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 27 of 56 The decon cycle will heat the incubator interior surfaces to approxim
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 28 of 56 SECTION 6 – OPTIONAL ACCESSORY OPERATION Using the Carboy Water Syst
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 29 of 56 Operation of the Delux Controller System (DLUX303) The chambers ca
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 3 of 56 TABLE OF CONTENTS Section 1 – Warranty ...
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 30 of 56 Analog Outputs: With DLUX303 controllers, there is an analog output
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 31 of 56 Set the Scale Low value to correspond with the minimum valu
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 32 of 56 The CO2 gas supply should be 99.5% pure and should not contain a siph
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 33 of 56 OUTL301 & OUTL302 Interior Electrical Outlet An optional inter
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 34 of 56 RCDR301/RCDR302 Built In Temp or Temp/Rh 6” Pen Recorders Built in 6
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 35 of 56 and metal pen arm be removed as an assembly. Unsnap the plastic "
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 36 of 56 If a calibration adjustment is required for a single pen recorder, us
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 37 of 56 RCDR303/RCDR304 Built In Temp or Temp/Rh 10” Thermal Recorders Built
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 38 of 56 move off of the chart allowing you to place the recording chart paper
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 39 of 56 Recorder Calibration: If calibration is required for single input r
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 4 of 56 Calibrating the Temperature Calibrating the Humidity Calibratin
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 40 of 56 RDCR305/RCDR306 Side Mounted Temp/Rh 10” Pen Recorder Side mounted
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 41 of 56 3. Lift the chart from the hub and locating pin and slide it from un
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 42 of 56 SECTION 7 – CALIBRATION The temperature, humidity, and CO2 syst
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 43 of 56 Calibrating the Humidity If humidity calibration is needed, the foll
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 44 of 56 Calibrating the CO2 If CO2 set-point calibration is required, the fo
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 45 of 56 SECTION 8 – ALARMS The incubators are equipped with an alarm system
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 46 of 56 SECTION 9 – PREVENTATIVE MAINTENANCE Your CARON incubator has been
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 47 of 56 SECTION 10 – SPECIFICATIONS MODEL 6024 6026 6044 6046 Temperature Ra
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 48 of 56 SECTION 11 – ELECTRICAL SCHEMATICS
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 49 of 56 SECTION 11 – ELECTRICAL SCHEMATICS
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 5 of 56 SECTION 1- WARRANTY INFORMATION CO2 INCUBATOR LIMITED WARRANTY Pleas
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 50 of 56 SECTION 11 – ELECTRICAL SCHEMATICS
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 51 of 56 SECTION 12 – TROUBLESHOOTING Problem -- Unit will not turn on Is
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 52 of 56 SECTION 13 – SPARE REPLACEMENT PARTS General Part Number Descriptio
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 53 of 56 SECTION 13 – SPARE REPLACEMENT PARTS (CONTINUED) CO2 Related Part N
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 54 of 56 SECTION 13 – SPARE REPLACEMENT PARTS (CONTINUED) Options Related Pa
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 55 of 56 The temperature, humidity, and CO2 controllers are factory programmed
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 56 of 56 Caron Products and Services, Inc. 27640 State Route 7 Marietta
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 6 of 56 This writing is a final and complete integration of the agreement betw
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 7 of 56 EQUIPMENT INTERNATIONAL LIMITED WARRANTY Please review this section b
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 8 of 56 This writing is a final and complete integration of the agreement betw
6024 & 6044 Series Operations Manual Rev F 02/14/12 Page 9 of 56 INTERNATIONAL SYMBOLS AND DEFINITIONS WAR
Comments to this Manuals